PERSONAL SAFETY CORPORATION
Mailing Address:
PO Box 128 • Hiawatha, IA 52233
Street Address:
1655 Progress Drive • Hiawatha, Iowa 52233
Phone: 888.843.6488 • Fax: 817.326.2389
Material Safety Data Sheet
PD-2, PD-3, PD-5
SSDS-2& SPG-1
******** WATER BASED PEPPER SPRAY + UV ********
1. CHEMICAL PRODUCT IDENTIFICATION
MSDS#: A09
REVISION DATE: 7/12/07
EDITION: 3
PRODUCT NAME: Water Based Pepper Spray
PRODUCT TYPE: Self Defense Irritant Spray
2. COMPOSITION INFORMATION ON INGREDIENTS
| Ingredient: |
CAS#: |
|
| WATER |
N/A |
|
| PROPYLENE GLYCOL |
57 – 55 - 6 |
|
| ISOPROPYL ALCOHOL |
67 – 63 - 0 |
|
| OLEORESIN CAPSICUM |
8023-77-6 |
|
| UV DYE |
N/A |
|
| NITROGEN |
7727-37-9 |
|
3. HAZARDS IDENTIFICATION
|
HMIS:
|
NFPA:
|
| HEALTH |
1 |
HEALTH HAZARD |
1 |
| FLAMMABILITY |
0 |
FIRE HAZARD |
0 |
| REACTIVITY |
0 |
INSTABILITY |
0 |
| PERSONAL PROTECTION: |
Gloves, goggles, |
SPECIFIC HAZARD |
Contents under pressure -Contents will discharge under fire conditions. |
NOTE: HMIS and NFPA ratings involve data and interpretations that may vary from company to company. They are intended only for rapid, general identification of the magnitude of the specific hazard. To deal adequately with the safe handling of this material, all the information contained in this MSDS must be considered.
4. FIRST AID
| INHALATION: |
Remove to fresh air. Give artificial respiration or oxygen if needed. If symptoms persist consult a physician. |
| EYES: |
Remove contact lenses and flush with plenty of water for at least 15 minutes. If symptoms persist contact a physician. |
| SKIN: |
Remove contaminated clothing. Flush with water for 15 minutes. Wash with soap and water. Do not cover effected area or use creams or ointments for 6 hours. |
| INGESTION: |
Do not induce vomiting. Take immediately to a hospital or physician. |
5. FIRE FIGHTING MEASURES
FLASH POINT: None when tested in accordance with DOT requirements.
(% BY VOLUME IN AIR) LOWER: 0
(% BY VOLUME IN AIR) UPPER: 0
RECOMMENDED EXTINGUISHING AGENTS: N/A
HAZARDOUS PRODUCTS FORMED BY FIRE OR THERMAL DECOMPOSITION: Irritating fumes.
UNUSUAL FIRE OR EXPLOSION HAZARDS: Contents will discharge in fire.
COMPRESSED GASES: Nitrogen
PRESSURE AT ROOM TEMPERATURE: 120 PSIG
6. ACCIDENTAL RELEASE MEASURES
STEPS TO BE TAKEN IN CASE OF SPILL OR LEAK: Absorb on appropriate sorbant, Provide increased ventilation
HANDLING: Handle with care, KEEP OUT OF THE REACH OF CHILDREN.
STORAGE: Store below 100 F. in shipping carton provided.
8. EXPOSURE CONTROLS/PERSONAL PROTECTION
EYES: Splash goggles.
SKIN: Protective clothing.
VENTILATION: Adequate or forced ventilation.
NOTE: FIRE FIGHTING PERSONNEL MUST USE AIR PACK.
9. PHYSICAL AND CHEMICAL PROPERTIES
VAPOR PRESSURE @ 70 F: <10 mmHg @ 68 F.
VAPOR DENSITY (AIR=1): .>1
SOLUABILITY IN WATER (WT%): 100%
SPECIFIC GRAVITY (H2O=1): 0.9 25/25 C
BOILING POINT: 190 F.
EVAPORATION RATE (ETHER=1): < 1
PH: 6-8
APPEARANCE: Clear red liquid
ODOR: Slight sweet odor with pungent, peppery overtone.
WEIGHT % VOLATILE: 60
10. STABILITY AND REACTIVITY
STABILITY: Stable at ambient temperatures.
HAZARDOUS POLYMERIZATION: Will not occur.
HAZARDOUS DECOMPOSTON PRODUCTS (NON-THERMAL): None
INCOMPATABILITY: Strong oxidizers, Finely Divided Alkaline Metals, Strong Acids and Strong Alkalis
11. TOXICOLOGICAL INFORMATION
TOXICITY: Strong skin and eye irritant. Oral LD 50 (RAT) <5 GM/KG not toxic per 16 CFR, Section 1500.3 (5)
PRIMARY ROUTES OF ENTRY: Inhalation, skin, ingestion.
SIGNS AND SYMPTOMS OF EXPOSURE: Respiratory and skin irritation. High inhaled amounts can cause dizziness; skin contact can cause local irritation, or general allergic reaction in sensitive individuals.
EXISTING CONDITIONS AGGRAVATED BY EXPOSURE: Certain allergies in sensitive individuals.
EXPOSURE LIMITS (for ingredients):
ISOPROPYL ALCOHOL: OSHA TWA 400 PPM, STEL 500 PPM
TARGET ORGANS (for ingredients):
ISOPROPYL ALCOHOL: Ocular, Gas
OLEORESIN CAPSICUM: Irritant, Allergen, Ocular
PROPYLELE GLYCOL: Gas
12. ECOLOGICAL INFORMATION
No specific ecological data area available for this product. Please refer to Section 6 for information regarding accidental releases.
13. DISPOSAL CONSIDERATIONS
Dispose of in accordance with all federal, state, and local environmental laws.
14. TRANSPORT INFORMATION
DOT STATUS: N/A
PROPER SHIPPING NAME: Consumer Commodity
I.D. NUMBER: ORM-D
REPORTABLE QUANITY: None
15. REGULATORY INFORMATION
TOXIC SUBSTANCE CONTROL ACT (TSCA): All ingredients are on the TSCA Inventory or are not required to be listed on the TSCA Inventory.
DISCLAIMER:
The supplier provides no warranty and no guarantee; either express or implied, and assumes no responsibility for the accuracy or completeness of the data contained herein. Safe handling and use of this product remains the responsibility of the user. No suggestions for use are intended as, and nothing herein shall be construed as, a recommendation to infringe upon any existing patents or violate any Federal, State or local laws.
|
